16万m3原油储罐基础沉降计算及施工方案的确定
Foundation Settlement Calculation and Construction Scheme Determination of 16 × 10~4 m~3 Oil Storage Tank
浏览(2360) 下载(4)
- DOI:
- 作者:
- 高飞, 张敏
GAO Fei
- 作者单位:
- 中国石油工程建设公司, 北京 100120
China Petroleum Engineering & Construction Co.,Ltd,Beijing 100120,China
- 关键词:
- 钢质储罐;Plaxis软件;模型构造;沉降计算;预压法;强夯法
steel tank;software Plaxis;modeling settlement calculation;preloading;dynamic compaction method
- 摘要:
- 阿布扎比原油管道项目的2座16万m3浮顶原油储罐位于沙漠中,地质结构复杂,储罐自身荷载大,罐基础设计难度大。文章详细介绍了这2座储罐罐基础的沉降计算,通过对地质结构、储罐构造和荷载的计算分析,针对不同地层分别确定模型参数,利用Plaxis软件构造了二维储罐基础沉降模型,计算得出罐底部沉降曲线;通过计算沉降量与沉降标准的对比,拟采用预压法和强夯法相结合的施工方案,以控制沉降量;经现场试夯前后试验结果的对比,确定强夯施工方案及参数;证明强夯对于改善罐底部基础机械特性和控制沉降量的效果是显著的,设计的罐基础施工方案可以满足对沉降量的控制要求。
This article describes the foundation settlement calculation of two 16 × 104 m3 floating roof tanks located in desert which belong to Abu Dhabi crude oil pipeline project.A 2-D axisymmetric model was created for each tank by applying the software Plaxis based on the research of ground condition,tank configurations and loads.The settlement curve of tank foundation was calculated based on modeling parameters of different layers.Preloading and dynamic compaction(DC) were adopted to control the settlement after making the comparison of the calculated settlement with the criteria.DC construction procedure and parameters were confirmed by the comparison of test results before and after the DC trail.It is concluded that DC has an obvious effect to improve the mechanical characteristics and settlement control,and the construction procedure adopted is satisfactory for settlement control.2001,1(1): 50-53,6 收稿日期：2010-1-13分类号：TE972作者简介：高飞(1983-),男,山西五寨人,工程师,2007年毕业于哈尔滨工业大学,从事国际石油工程建设管理工作.参考文献：
[1]API653(2005); Tank inspection,repair,alteration,and reconstruction Addendum 2[S].
[2]Clark I D,Fontes J C.Paleoclimatic reconstruction in Northern Oman based on carbonates from hyperalkaline ground waters[J].Quaternary Research,1990,(33):320-336.
[3]Glennei K W,Singhvi A K.Event stratigraphy,paleenvironment and chronology of SE Arabian deserts[J].Quaternary Science Reviews,2002,(21):853-869.
[4]Kukowski N,Schillborn T,Flueh E,et al.Newly identified strikeslip plate boundary in the northeastern Arabian Sea[J].Geology,2000,(28):355-358.
[5]Marr W A,Ramos J A.Criteria for settlement of tanks[J].Journal of the Geotechnical Engineering Division,ASCE,1982,108(GT8):1017-1039.
[6]Vita-Finzi C.New tectonics at the Arabian plate margins[J].Journal of Structural Geology,2001,(23):521-530.